502 surging and loading up?
#31
Registered
Thread Starter
Just got off the phone with the repair shop, they said the computer has no fault codes, said all sensors are functioning as should. Timing is set at 8 degrees, he did say the fuel pressure was a little low at 26psi so they are going to look into that. He did also say that 502mpi's are known for surging between 1000-1200rpms, of which Im not so sure what to think off.
#32
Registered
He did also say that 502mpi's are known for surging between 1000-1200rpms,
#33
Registered
Just got off the phone with the repair shop, they said the computer has no fault codes, said all sensors are functioning as should. Timing is set at 8 degrees, he did say the fuel pressure was a little low at 26psi so they are going to look into that. He did also say that 502mpi's are known for surging between 1000-1200rpms, of which Im not so sure what to think off.
The following users liked this post:
articfriends (11-20-2021)
#34
Registered
Thread Starter
Honestly pretty frustrated with the repair shop right now. Repair shop scheduled in for July 6, this was scheduled a month out. I finally called them at the end of the week and they said they did not have time to get to it and didnt think they would this week. I asked if I could pull it out and use it this weekend since summer is short and not loose my spot, his response is, "we will see what we can do". After further convo he agrees it will be right back in line, I dropped if back of sunday night, never heard anything. Called them tuesday the 13th and found out they had looked at it and they found the low fuel pressure but would have to figurie out what to do about that. I said thats fine, I am leaving for vacation tomorrow (the 14th) so you will have to leave me a voicemail. Almost another week goes by and I still havent heard from them, so on the 20th I call them wondering whats up, they respond with "its ready to be picked up, the low fuel pressure isnt anything that can be addressed and it is what it is". At this point Im frustrated and say fine whats my bill. He didnt have it completed yet but will call later with it. Later that same day a lady calls and tells me its $215. The very next morning i get a call wondering when I am picking it up because they are limited on space, then again that after noon reminding me to pick up. Like really, this things been there for weeks and you have yet once to call me and I told you I was on vacation.
So all in all i guessed I have learned that all 502s surge, and there is nothing to be done about low fuel pressure.
So all in all i guessed I have learned that all 502s surge, and there is nothing to be done about low fuel pressure.
#35
Registered
Crazy.
#36
Platinum Member
Platinum Member
Where are you located ?
#37
Registered
Tell em to choke on their $215!
low fuel pressure can be fixed!
Think it should be in the 38-43 range depending on app.
low fuel pressure can be fixed!
Think it should be in the 38-43 range depending on app.
The following 3 users liked this post by liberator221:
#39
Registered
Thread Starter
Well I took the boat out yesterday after picking it up from the marina, after cleaning all the grease stains of my brand new interior that is. Boat ran rough as usual, there was a couple instances going through no wake that it would stutter and I wondered if it was gonna recover. I took a video of it doing it but I cant upload it as it isnt the correct format. Another thing I noticed is after a 30 minute run, mostly no wake I shut it down for 10 minutes or so, after refiring it was steaming a ton from starboard side only. I havent noticed this before, it followed as we accelerated to the no wake zone and then for a few minutes into the no wake. Boat was running at 160 degrees, normally I would think riser/manifold gaskets but I just did those this spring as they were leaking externally. I would think if they were leaking internally it would also cause runability issues, however it isnt ever steaming when its running rough. Ive got a call into a couple other marinas now, but being the heat of the summer Im sure Ill be waiting until fall.
#40
Registered
Help Chasing Erratic Idle Please